Service Processor (ILOM ) reboots continuously reporting IO errors on T5x20 (Doc ID 1598815.1)

Last updated on JUNE 06, 2017

Applies to:

Sun SPARC Enterprise T5220 Server - Version All Versions and later
Sun SPARC Enterprise T5120 Server - Version All Versions and later
Sun Netra T5220 Server
Information in this document applies to any platform.

Symptoms

 -> reset /SP
Are you sure you want to reset /SP (y/n)? yes
Performing reset on /SP
INIT: Switching to runlevel: 6
INIT: Sendÿocesses the KILL sigîStopping portmap daemon: portmap.
Stopping Network Interface Plugging Daemon: eth0.
Stopping the Health Monitor Daemon...
Stopping Serial Server: seriald.
Stopping IPMI Stack...... Done.
Stopping OpenBSD Secure Shell server: sshd.
Stopping bbrd...
Stopping periodic command scheduler: cron.
Saving the System Clock time to the Hardware Clock...
Hardware Clock updated to Wed Oct 23 02:26:43 GMT 2013.
Unmounting remote and non-toplevel virtual filesystems...done.
Unmounting local filesystems...umount: /dev/tffsa1 busy - remounted read-only
done.
.
Sending all processes the TERM signal...done.
Sending all processes the KILL signal...done.
No firmware updates pending.
Rebooting...

U-Boot 1.1.1

custom Sun Microsystems U-Boot 1.3 (Sep  7 2012 - 15:55:17) r74569

<snip>


Warning: /lib/modules/2.4.22/misc/tffs/tffs_h3.o symbol for parameter prio not found
Warning: loading /lib/modules/2.4.22/misc/tffs/tffs_h3.o will taint the kernel: non-GPL license - Proprietary
  See http://www.tux.org/lkml/#export-tainted for information about tainted modules
tffs: TrueFFS driver 7100.76
tffs: will not use IRQ
tffs: Looking for G4/P4 MDOC Devices while assuming IF_CFG=16.
tffs: Looking for G4/P4 MDOC Devices while assuming IF_CFG=8.
tffs: Flow: G4_docWindowBaseAddress Exit (NOT FOUND).
tffs: Looking for G3/P3 MDOC Devices while assuming IF_CFG=16.
tffs: Looking for G3/P3 MDOC Devices while assuming IF_CFG=8.
tffs: Looking for H1 DOC at address 0xc914b000
tffs: DOCH found
tffs: Socket 0 in addr 0xf4000000
tffs: Device 0x0: size 0x76c0000 HW sector 0x200 (recommended 0x1000)
tffs: use major device number 100
Partition check:
 tffsa: tffsa1 tffsa2 tffsa3
tffs:     disk partition: dev_number=0x6401, 65534 sectors, start_sector=1
tffs:     disk partition: dev_number=0x6402, 65536 sectors, start_sector=65535
tffs:     disk partition: dev_number=0x6403, 112000 sectors, start_sector=131071
Module tffs_h3 loaded, with warnings
Loaded TFFS kernel module /lib/modules/2.4.22/misc/tffs/tffs_h3.o
tffs: flAbsWrite error 29
end_request: I/O error, dev 64:01 (tffs), sector 548
kjournald starting.  Commit interval 5 seconds
EXT3-fs warning: checktime reached, running e2fsck is recommended
tffs: flAbsWrite error 29
end_request: I/O error, dev 64:01 (tffs), sector 2
EXT3 FS 2.4-0.9.19, 19 August 2002 on tffs(100,1), internal journal
EXT3-fs: recovery complete.
tffs: flAbsWrite error 29
end_request: I/O error, dev 64:01 (tffs), sector 548
EXT3-fs: mounted filesystem with ordered data mode.
kjournald starting.  Commit interval 5 seconds
EXT3-fs warning: checktime reached, running e2fsck is recommended
EXT3 FS 2.4-0.9.19, 19 August 2002 on loop(7,0), internal journal
EXT3-fs: recovery complete.
EXT3-fs: mounted filesystem with ordered data mode.
kjournald starting.  Commit interval 5 seconds
EXT3-fs warning: checktime reached, running e2fsck is recommended
EXT3 FS 2.4-0.9.19, 19 August 2002 on loop(7,1), internal journal
EXT3-fs: mounted filesystem with ordered data mode.
kjournald starting.  Commit interval 5 seconds
EXT3-fs warning: checktime reached, running e2fsck is recommended
EXT3 FS 2.4-0.9.19, 19 August 2002 on loop(7,2), internal journal
EXT3-fs: recovery complete.
EXT3-fs: mounted filesystem with ordered data mode.
kjournald starting.  Commit interval 5 seconds
EXT3-fs warning: checktime reached, running e2fsck is recommended
tffs: flAbsWrite error 29
end_request: I/O error, dev 64:01 (tffs), sector 548
tffs: flAbsWrite error 29
end_request: I/O error, dev 64:01 (tffs), sector 2648
EXT3 FS 2.4-0.9.19, 19 August 2002 on loop(7,3), internal journal
tffs: flAbsWrite error 29
end_request: I/O error, dev 64:01 (tffs), sector 2658
tffs: flAbsWrite error 29
end_request: I/O error, dev 64:01 (tffs), sector 2902
tffs: flAbsWrite error 29
end_request: I/O error, dev 64:01 (tffs), sector 10836
end_request: I/O error, dev 64:01 (tffs), sector 10838
tffs: flAbsWrite error 29

kjournald starting.  Commit interval 5 seconds
EXT3-fs warning: checktime reached, running e2fsck is recommended
EXT3 FS 2.4-0.9.19, 19 August 2002 on loop(7,4), internal journal
tffs: flAbsWrite error 29
end_request: I/O error, dev 64:01 (tffs), sector 554
EXT3-fs: mounted filesystem with ordered data mode.
tffs: flAbsWrite error 29
end_request: I/O error, dev 64:03 (tffs), sector 32770                   <<<<<<<<<
tffs: flAbsWrite error 29
end_request: I/O error, dev 64:03 (tffs), sector 32774                   <<<<<<<<<
tffs: flAbsWrite error 29
end_request: I/O error, dev 64:03 (tffs), sector 35930                   <<<<<<<<<
tffs: flAbsWrite error 29
end_request: I/O error, dev 64:03 (tffs), sector 2
end_request: I/O error, dev 64:03 (tffs), sector 4
tffs: flAbsWrite error 29
end_request: I/O error, dev 64:03 (tffs), sector 536
kjournald starting.  Commit interval 5 seconds
EXT3-fs warning: checktime reached, running e2fsck is recommended
tffs: flAbsWrite error 29
end_request: I/O error, dev 64:03 (tffs), sector 2
EXT3 FS 2.4-0.9.19, 19 August 2002 on tffs(100,3), internal journal
EXT3-fs: recovery complete.
tffs: flAbsWrite error 29
end_request: I/O error, dev 64:03 (tffs), sector 536
EXT3-fs: mounted filesystem with ordered data mode.
Mounted all disk partitions.
tffs: flAbsWrite error 29
end_request: I/O error, dev 64:01 (tffs), sector 2610
tffs: flAbsWrite error 29
end_request: I/O error, dev 64:01 (tffs), sector 566
Image date:  Fri Sep  7 17:31:26 PDT 2012       Image revision: 74569
Conf date:   Fri Sep  7 17:31:26 PDT 2012       Conf revision:  74569
Configuration files state good after upgrade.
Loaded IFC configuration file.
EXT3-fs error (device loop(7,3)): ext3_free_blocks: bit already cleared for block 1442
EXT3-fs error (device loop(7,3)): ext3_new_block: Allocating block in system zone - block = 55
tffs: flAbsWrite error 29

<snip>


Starting system log daemon: syslogd and klogd.
Starting capidirect daemon:   Done
Starting Boot Timer.
Starting user mgmt upgrade program: usrmgt_upgrade.
Starting the Health Monitor Daemon...
Starting portmap daemon: portmap.
Starting capidirectd: Done.
Starting Network Interface Plugging Daemon: eth0.
Starting IPMI Stack...... Done.
SSH RSA Host Key Files already exist. Skipping key creation ...
SSH DSA Host Key Files already exist. Skipping key creation ...
Starting sshd.
Starting BBR daemon...
bbrd started after 1 seconds.
Starting periodic command scheduler: cron.
Starting Serial Server :seriald .
Starting Servicetags discoverer: stdiscoverer.
Starting Servicetags listener: stlistener.

tiauthcd1ffd-ilom login: fopen: Input/output error
fopen: Input/output error


Cause

Sign In with your My Oracle Support account

Don't have a My Oracle Support account? Click to get started

My Oracle Support provides customers with access to over a
Million Knowledge Articles and hundreds of Community platforms